冬季可以说是自上料搅拌车容易出现故障的季节，当然大家都知道，好的车况离不开我们日常对设备的细心维护。那么自动上料搅拌车在冬季时如何维护呢？下面来看看吧。

　　Winter can be said to be the season when the mixing truck is prone to failure. Of course, as we all know, good car condition cannot be separated from our daily careful maintenance of equipment. So how to maintain the automatic feeding mixer in winter? Take a look.

　　在冷启动时，请一定记得怠速空载运行5-10分钟(严寒季节15-20分钟)，然后再往复低速空载运行3~5次，待系统充分预热后再开始工作。自上料搅拌车启动前务必检查操纵装置的操纵手柄是否置于停止位置，倘若发动机启动时罐子处于高速旋转状态，瞬间产生的力会非常大，将极易造成减速机和泵马达系统的损伤。

　　In the cold start, please remember idle idle idle for 5-10 minutes (15-20 minutes in the cold season), and then reciprocating low speed no-load operation for 3~5 times, until the system fully warm up before starting to work. Be sure to check whether the handle of the control device is placed in the stop position before starting the feeding mixer. If the tank is in a state of high speed rotation when the engine starts, the instantaneous force will be very large, which will easily cause damage to the reducer and pump motor system.

　　冬季雨雪天气也会较为频繁的出现，大家在行驶过程中，一定要注意安全，保持车距。随时观察路面结冰情况，提前减速，缓行通过。雨雪天气行车时，更要保持好车距，切勿空挡滑行、急打方向、猛踩刹车。

　　Winter rain and snow weather will be more frequent, we must pay attention to safety in the process of driving, keep the distance from the car. Observe the ice situation on the road at any time, slow down in advance, slowly through. Rain and snow weather driving, but also to maintain a good distance, do not slide in neutral, hit the direction, slam on the brakes.

　　冬季施工时，由于环境温度低的原因，自上料搅拌车的运转处于不利的工况，液压油低温时粘度增大，使管路油流阻力和泵吸油阻力增大，在操作时应特别注意此种情况，以避免损坏设备。

　　In winter construction, due to the low ambient temperature, the operation of the mixing truck is in an unfavorable condition. The viscosity of hydraulic oil increases at low temperature, which increases the resistance of pipeline oil flow and pump oil absorption. Special attention should be paid to this situation during operation to avoid damage to the equipment.

　　另外，冬季用车应保持车身干净整洁，因保温罐衣的原因，应及时检查减速机与罐体连接的缝隙处是否有等异物，如果有的话，需及时清理，避免勒坏油封造成漏油。

　　In addition, winter car should keep the body clean and tidy, due to the reasons of thermal insulation tank clothes, should timely check whether there are foreign bodies at the gap between the reducer and the tank body, if there is, need to be cleaned in time, to avoid bad oil seal caused by oil leakage.

　　冬季起步请一定要十分柔和缓慢，不要直接一脚油门就往前冲。这样一方面是为了让自动上料搅拌车发动机在未达到正常运转温度时负载尽量小，另一方面也是让轮胎在没热起来，还处于较硬的状态下的时候，有一个渐热的过程。柔和的起步方式对自上料搅拌车发动机、轮胎及安全都有好处。启动前也需要确保控制手柄处于停止位置，避免带载启动对液压系统造成冲击损伤。

　　Winter start please be very soft and slow, do not directly a foot throttle forward. On the one hand, this is to make the load as small as possible when the engine of the loading agitator does not reach the normal operating temperature, on the other hand, it is also to make the tire not hot, but also in a hard state, there is a process of gradual heating. A gentle start is good for the engine, tires and safety of the self-loading agitator. Before starting, it is also necessary to ensure that the control handle is in the stop position to avoid impact damage to the hydraulic system caused by starting with load.

　　当然会有人问到，冬季了，我家的自动上料搅拌车就不用工作了，限制在库房中应该不需要维护了吧，其实这是一个误区，当停用后再次启用自上料搅拌车前，要对整体润滑系统逐一检查，必要时加油或换油。还有不懂的地方就来网站www.jfhntjbj.com咨询吧。

　　Of course, some people will ask, in winter, my automatic feeding mixer does not need to work, limited in the warehouse should not need to maintain it, in fact, this is a misunderstanding, when it is used again since the feeding mixer, to check the overall lubrication system one by one, if necessary, refueling or oil change. Still do not understand the place to the website www.jfhntjbj.com consultation.