At present, there are three types of automatic feeding mixers: wet materials, dry materials and semi dry materials. If the concrete loader is not operated safely, rollover and hydraulic pump will occur. The wear of motor and reducer is too fast, which may even cause serious consequences. The following small series of articles introduce the following contents according to the safety operation rules to be followed when using the self loading mixer:

1.搅拌筒的旋转方向必须与箭头方向一致。如果不正确，则需要更正电动机接线。

1. The rotation direction of the mixing drum must be consistent with the direction of the arrow. If not, correct the motor wiring.

2.设备齐全的混合器必须实施二次泄漏保护。打开电源后即可上班，因此请仔细检查。仅在通过空车测试后才能使用。在调试期间，请确保混合罐的速度正确。通常，空车（装载后）的速度比几转弯稍快。如果相差很大，则需要调整驱动轮与驱动轮的比率。

2. The mixer with complete equipment must be protected against secondary leakage. You can go to work after turning on the power, so please check carefully. It can only be used after passing the empty vehicle test. During commissioning, please ensure that the mixing tank speed is correct. Generally, the speed of an empty vehicle (after loading) is slightly faster than that of a few turns. If there is a large difference, the ratio of drive wheel to drive wheel needs to be adjusted.

3.搅拌机轨道应平放。用一棵方形树抬起前后轴，使轮胎直立，以免轮胎在开始时移动。

3. The mixer track shall be placed horizontally. Lift the front and rear axles with a square tree to keep the tire upright so that the tire does not move at the beginning.

4，.变速箱离合器，制动器是否灵活可靠，钢丝绳是否完好，履带轮是否完好，周围是否有障碍物，各部位的润滑确保。

4. Whether the gearbox clutch and brake are flexible and reliable, whether the steel wire rope is intact, whether the crawler wheel is intact, whether there are obstacles around, and whether the lubrication of all parts is ensured.

5.如果您正在搅拌混凝土，或者您打算停止搅拌一个小时以上（除了其余材料），则将石头和水倒入桶中，将其打开，洗掉粘附在桶上的砂浆并沥干所有东西。去做。枪管中应该没有水，以防止枪管和刀片生锈。同时，必须积聚在混合罐外部的灰烬，并保持机器清洁并保持良好状态。

5. If you are mixing concrete, or you intend to stop mixing for more than an hour (except for other materials), pour stones and water into the bucket, open it, wash off the mortar adhered to the bucket and drain everything. Do it. There should be no water in the barrel to prevent the barrel and blade from rusting. At the same time, ash accumulated outside the mixing tank must be removed and the machine must be kept clean and in good condition.

6.启动后，请注意调音台各部分的正常运行。关闭时，请始终检查搅拌机叶片是否弯曲，拧松或松动。

6. After startup, please pay attention to the normal operation of all parts of the mixer. When closing, always check whether the mixer blades are bent, loosened or loose.

7.下班后，不使用机器时，有必要关闭电源并锁定开关盒，以确保。

7. After work, when the machine is not used, it is necessary to turn off the power supply and lock the switch box to ensure safety.

以上是使用自动上料搅拌车时要遵循的操作规则。我认为以后使用会更加谨慎。需要更多信息吗？请继续关注我们http://www.jfhntjbj.com

The above are the safety operation rules to be followed when using automatic feeding mixer. I think it will be used more carefully in the future. Need more information? Please continue to follow us http://www.jfhntjbj.com