The operator of automatic loading mixer truck is mainly responsible for the daily production of concrete mixing equipment. The operator should have practical operation experience in the mixing plant and be familiar with the equipment software, PLC and other operations of the mixing plant. Here is a summary of the post responsibilities of the computer operator of automatic loading mixer truck.

一、 混凝土搅拌楼电脑操作工必须严格遵守公司的一切规章制度。

1、 The computer operator of concrete mixing plant must strictly abide by all rules and regulations of the company.

二、 严禁将本公司的砼配合比资料及原材料对外泄露，一旦发现坚 决给予开除

2、 It is strictly prohibited to disclose the concrete mix proportion data and raw materials of the company. Once found, it shall be resolutely dismissed

三、 每次开机前，必须对搅拌机检查是否正常，查看交接班记录， 巡视一切正常后方可开机。

3、 Before starting up each time, check whether the mixer is normal, check the shift handover record, and start up only after everything is normal.

四、 操作工开工前必须对操作室预热，然后打打铃3次，每次不得 少于3秒。

4、 The operator must preheat the operation room before starting work, and then ring the bell for 3 times, each time not less than 3 seconds.

五、 严格按配合比单正确操作电脑，不能随意更改配合比单，如需 更改必须由试验室人员现场监督签字。

5、 Operate the computer correctly in strict accordance with the mix proportion sheet, and do not change the mix proportion sheet at will. If it needs to be changed, it must be signed by the laboratory personnel on site.

六、 严格按调度规定的指令发出信号，即：生产前、装料前、装料 后发出铃声。

6、 Send signals in strict accordance with the instructions specified by the dispatcher, i.e. ring before production, before loading and after loading.

七、 正常工作2小时，操作工必须巡视搅拌机，清理搅拌机。

7、 When working normally for 2 hours, the operator must patrol the mixer and clean it.

八、 若有听到异响或闻到异味必须立即停机，及时向上级汇报。

8、 If you hear abnormal noise or smell peculiar smell, you must stop the machine immediately and report to the superior in time.

九、 危险部位维修或抢修时，必须停机后把操作台上控制钥匙交到 施工人员手中，并且操作工在现场监督。

9、 In case of repair or emergency repair of dangerous parts, the control key on the console must be handed over to the construction personnel after shutdown, and the operator shall supervise on site.

十、 密切注意操作台上各种数据的变化，发现有异常情况及时通知 相关人员进行故障排除。

10、 Pay close attention to the changes of various data on the console, and timely notify relevant personnel for troubleshooting in case of abnormalities.

十一、 操作工报废料时，必须由主管导同意，查看原因所在， 并如实填写材料报废登记表

11、 When the operator reports the waste, he must be approved by the supervisor, check the reason, and truthfully fill in the material scrap registration form

十二、 操作室严禁吸烟，设备要求清洁，严禁无关人员进入操作 室，如有违章按公司处罚条例执行。

12、 Smoking is strictly prohibited in the operation room. The equipment shall be clean. Irrelevant personnel are strictly prohibited from entering the operation room. In case of violation, the punishment regulations of the company shall be implemented.

十三、 操作室内严禁放与生产无关的东西，严禁在电脑上玩游戏 或光盘；电脑上所有设置不允许随意改动。

13、 It is strictly prohibited to put anything irrelevant to production in the operation room, and it is strictly prohibited to play games or CDs on the computer; All settings on the computer are not allowed to be changed at will.

十四、 不装料时，操作员严禁离开自己的岗位，保证岗不离人， 如有违章按公司离岗条例处罚。 十五、 操作时发现有明显的产品质量问题，应及时停机，由试验 室来确定。

14、 When not loading, the operator is strictly forbidden to leave his post and ensure that he will not leave his post. If there is any violation, he shall be punished according to the company's regulations on leaving his post. 15、 If obvious product quality problems are found during operation, the machine shall be shut down in time and determined by the laboratory.

十六、 做好相关工作时必须以为前提，确认后方可开工。

16、 Safety must be taken as the premise when doing relevant work, and the construction can be started only after confirming safety.

十七、 保持搅拌楼和操作室整洁卫生，收工时必须对搅拌机 清洗，所有电源必须切断，门窗锁好、关严。

17、 Keep the mixing plant and operation room clean and tidy. The mixer must be cleaned at the end of work. All power supplies must be cut off, and the doors and windows must be locked and tightly closed.

十八、 认真做好搅拌楼生产记录及原材料消耗情况。

18、 Carefully make production records and raw material consumption of the mixing plant.

十九、 认真完成组长交给的临时工作任务。

19、 Earnestly complete the temporary tasks assigned by the team leader.

二十、 及时配合机修工对设备的维护、检修等工作

20、 Timely cooperate with the mechanic to maintain and repair the equipment